TCS Court Color
Surface Preparation:
Pavement surface must be cleaned entirely of dust, dirt and debris.
Repair of pavement surface defects, depressions, and cracks should be
complete prior to application. All repairs must be flush and smooth to
adjoining surfaces for best results. New asphalt must cure 14-30 days
and new concrete must cure 28 days prior to applications. It is
recommended that any uncoated/bare surface receive one or more coats of
TCS Court Resurfacer as required by surface roughness and porosity to
provide a smooth, dense underlayment for application of color coatings.
Concrete surfaces should have a medium broom finish or similar roughened
texture. Etch surface with muriatic or phosphoric acid and apply TCS
Acrylic Adhesion Promoter, prior to color coating.
Mixing Procedures: Mix materials to a smooth, uniform
consistency. The following mix designs are based on 10 gallons of TCS
Court Color for ease of calculation.
Court Color ...................................10 Gallons
Silica Sand (80-90 mesh AFS)........70-80 Pounds
Water..............................................5-6 Gallons
Application: Apply
with a soft rubber squeegee. A minimum of two coats of TCS Court Color
are recommended for desired color, hiding, and durability.
Important:
Stir material thoroughly before using. Temperatures must be a minimum
of 50ºF and rising both during application and for a period of at least
24 hours after applications. Do not apply when rain is imminent in the
forecast. Keep from freezing. Close container when not in use.
Coverage:
Yield calculations are based on undiluted gallons of TCS Court Color
and vary according to surface texture and porosity within the limits
below: .05 to .08 per sq. yard per coat.
Drying Time:
TCS Court Color dries in 30-60 minutes under optimum drying conditions.
Low ambient or low surface temperature, shade, and high humidity
increase drying time.
Clean Up: Wash tools in water before material dries.
VOC: This material contains less than 100 grams of volatile organic compounds per liter.
Caution: KEEP
FROM FREEZING. KEEP OUT OF REACH OF CHILDREN. Do not take internally.
If swallowed, call a physician immediately. In case of contact with
eyes, flush immediately with water for 15 minutes and call a physician.
Do not apply when rain is imminent. When not in use, keep container
tightly closed and upright to prevent leakage. Do not store in direct
sunlight or above 100 ºF. In case of spillage, absorb and dispose of in
accordance with Federal, State and Local regulations.
Warranty:
The statements made on this label are believed to be true and accurate
and are intended to provide a guide for approved application practices.
As workmanship, weather, construction, equipment utilized and other
variables affecting results are all beyond our control. Tennis Court
Supply warrants only that the material conforms to product
specifications and any liability to the buyer or use of this product is
limited to the replacement value of the product only. In no event shall
tennis court supply be liable for any injury, loss or damage, either
direct
or incidental, special or consequential, however arising in connection
with material or equipment furnished or work performed. Tennis Court
Supply shall not, in any manner, be liable for any defects, variations
or change in condition in the substructure over which its products are
installed.
Colors Available: Dark Green, Medium Green, Light Green, Red, Beige, Grey, Maroon, Blue, Brown